Material Safety Data Sheet
Section 1 Product Identification
Manufacturer
DTW Innovative Solutions, Inc. 5815 N Cypress Ave
Kansas City, MO 64119
Emergency Phone Number
(816) 453-7575 8:00 AM
- 9:00 P.M. CST
Product Name
Spectrum
The Environmental Safe "Tougher Cleaner System"
Chemical Name
Blended Mixture
Proprietary Formulation
Section 2 Ingredients -
Concentrate Components
Nonylphenol Ethoxylate
CAS #
ACGIHTLV OSHA PEL
%
09016-45-9 NE NE
NE
< 1.0
2, Butoxy Ethanol
CAS #
ACGIH TLV OSHA PEL
%
11-76-2
25 PPM 25 PPM
< 2.0
Potassium Hydroxide
CAS #
ACGIH TLV OSHA PEL
%
001310583 2 mg/m3
2 mg/m3 <
1.0
Sodium Hydroxide
CAS #
ACGIH TLV OSHA PEL
%
11310-73-2 2 mg/m3
2 mg/m3
< 1.0
Sodium Metasilicate
CAS #
ACGIH TLV OSHA PEL
%
6834-92-0 2 mg/m3
2 mg/m3
< 2.0
D-Limonene
CAS #
ACGIH TLV OSHA PEL
%
5989-27-5
NE
NE
< 1.0
Alcohol Ethoxylate Detergent
CAS #
ACGIH TLV OSHA PEL
%
34398-01-1
NE
NE
< 5.0
Anionic Surfactant
Alcohol Ethoxysulfate
CAS #
ACGIH TLV OSHA PEL
%
68585-34-2
NE
NE
< 1.0
Ethanol
CAS #
ACGIH TLV OSHA PEL
%
64-17-5 1,000
PPM 1,000
PPM < 1.0
NE - Not Established
Section 3 Physical Data
Boiling Point
212 Deg. F
Vapor Density
> 1 (Air = 1)
Vapor Pressure
Not Determined or Unknown
Specific Gravity
1.039 @ 77 Deg. F
Solubility in Water
Complete
Appearance & Odor Neutral Liquid - Mild
Citrus
H M I S
H-1; F-1; R-0; P-X
Sensitive skin-cuts / scrapes: Wear rubber gloves
when using very heavy mixture or heavy acetic acid mixtures - may cause
slight burning.
Section 4 Fire & Explosion Data
Flash
Point (Method) > 160º F (PMCC)*
Flammable
Limits (% Volume
In Air = NA)
Small Containers (5 Gallon or less) are non flammable
when stored in open - well ventilated area.
Extinguishing Media
Water
spray, foam, carbon dioxide or dry chemical may be used where this product
is stored. * Flash Point and Flammability are attributable to the Butyl
Alcohol, Ethanol, and D-Limonene content in this product.
Special Fire
Fighting Procedures
Cool fire exposed containers with water.
Section 5 Reactivity Data
Stability.............................................................Stable
Hazardous Decomposition Products.....................N/A
Conditions To
Avoid:
1. Spraying in non ventilated area. Large concentration of vapor
build up - contains mild surfactants.
2. Using Heavier Dilutions
without gloves with cuts, scrapes, or sensitive skin - may cause slight
burning.
3. Mixing Bleach, Vinegar, or Hydrogen Peroxide formulations
together - toxic gases can be released.
Section 6 Health Hazards
Possible
Routes of Entry
Inhalation?
Skin?
Ingestion?
Yes
Yes
Possible but not probable
Carcinogencity
NTP?
IARC?
OSHA?
No
No
No
Eyes: Liquid concentrate may cause mild damage if not thoroughly
flushed with water.
Skin Absorption: Prolonged or repeated exposure
may cause slight skin dermatitis and / or dryness. May cause slight burning
on cuts and scrapes.
Ingestion: Small amounts swallowed incidental
to normal handling are not likely to cause injury, however, swallowing larger
amounts may cause throat and stomach irritation.
Inhalation: The
major hazardous ingredients are not volatile, therefore, inhalation of the
vapors should be harmless. Heavy mist concentrations in enclosed non ventilated
areas may cause chest discomfort or slight coughing.
Section 7 FIRST AID
Eyes:
Irrigate with flowing water for 15 minutes, including under eyelids. If
irritation persists, get medical attention immediately.
Skin:
Wash thoroughly with soap and water - use quality lotion for dry skin.
Ingestion: Never give anything by mouth to an unconscious person.
Immediately dilute by drinking large quantities of water. If available,
give several glasses of milk. Do not induce vomiting. Get medical attention.
Section 8 Spill - Leak Procedures
Eliminate all ignition sources. Handling equipment should be grounded to
prevent sparking. Recover as much cleaner as practical. Material should
be mopped up and flushed into the sewer with copious amounts of water. Caution:
Material is slippery on hard or wet surfaces.
This Safety
Data Information was prepared on December 14, 2014
While we
believe that the data contained herein is factual and the opinion expressed
are those of qualified experts, the data is not to be taken as a warranty
or representation for which the company assumes legal responsibility. They
are offered solely for your consideration, investigation, and verification.
Any use of this data & information must be determined by the user to be
in accordance with applicable Federal, State, and Local laws and regulations.
Top
|
